Auto Recalls for Consumers

CHEVROLET KODIAK Recalls - View the latest CHEVROLET KODIAK Recalls from the NHTSA

 
Auto Recalls For Consumers
by General Motors LLC

CHEVROLET KODIAK RECALLS - (26 Recalls Found)

Since 1969, CHEVROLET has issued a total of 2957 car recalls worldwide. Of those recalls, 26 have been for the CHEVROLET KODIAK starting in 1994. This accounts for approximately 8.8% of the 33779 car recalls issued by the NHTSA since 1966. The KODIAK accounts for less than 1.0% of all the CHEVROLET recalls issued since 1969. Compared to other car manufacturers, CHEVROLET ranks #2 in overall number of recalls issued by a car maker.

Please keep in mind these numbers are for statistical purposes only & do not necessarily reflect the quality of the CHEVROLET KODIAK or CHEVROLET itself. These figures are based only on the number of recalls issued and NOT the total number of vehicles affected by a particular recall.

Find your CHEVROLET KODIAK listed below. Results are sorted year from newest to oldest. Select the desired CHEVROLET KODIAK to view the complete recall details. Information provided by the National Highway Traffic Safety Administration.

RSS Feed for CHEVROLET KODIAK


View CHEVROLET KODIAK Recalls Below ↓
2008 Recalls ↓

2008 CHEVROLET KODIAK Recall - ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Problem: GM IS RECALLING 319 MY 2008 CHEVROLET KODIAK AND GMC TOPKICK TRUCKS EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK. Recall Details - 8/6/2008
2007 Recalls ↓

2007 CHEVROLET KODIAK Recall - SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR

Problem: GM IS RECALLING 1,880 MODEL YEAR 2007 CHEVROLET KODIAK AND T-SERIES, GMC TOPKICK AND T-SERIES, AND ISUZU F-SERIES AND H-SERIES PASSENGER VEHICLES EQUIPPED WITH 7.8L DIESEL ENGINE. THE AIR COMPRESSOR IN SOME OF THESE VEHICLES MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLES WAS STATIONARY (BRAKES APPLIED), THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING.Recall Details - 7/29/2009

2007 CHEVROLET KODIAK Recall - STEERING

Problem: ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.Recall Details - 10/4/2007

2007 CHEVROLET KODIAK Recall - POWER TRAIN:AXLE ASSEMBLY

Problem: ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS AND, AS A RESULT, IT COULD DEVELOP A CRACK. Recall Details - 4/10/2007

2007 CHEVROLET KODIAK Recall - SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR

Problem: ON CERTAIN MEDIUM DUTY CONVENTIONAL AND TILT CAB TRUCKS EQUIPPED WITH 7.8L DIESEL ENGINES AND AIR BRAKES, THE AIR COMPRESSOR MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM.Recall Details - 5/2/2007

2007 CHEVROLET KODIAK Recall - PARKING BRAKE

Problem: ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY. Recall Details - 8/28/2007
2006 Recalls ↓

2006 CHEVROLET KODIAK Recall - PARKING BRAKE

Problem: ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY. Recall Details - 8/28/2007

2006 CHEVROLET KODIAK Recall - PARKING BRAKE:CONVENTIONAL:AIR

Problem: CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.Recall Details - 7/13/2006

2006 CHEVROLET KODIAK Recall - ENGINE AND ENGINE COOLING

Problem: ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER. Recall Details - 8/3/2006

2006 CHEVROLET KODIAK Recall - SERVICE BRAKES, AIR

Problem: CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." AN INTERNAL CONTROL AND CHECK VALVE WITHIN THE AIR BRAKE APPLICATION VALVE ASSEMBLY WAS CONFIGURED IMPROPERLY, PREVENTING AIR FROM FLOWING THROUGH THE BRAKE SYSTEM AS DESIGNED. IN THE EVENT OF AN EMERGENCY STOP, THE VEHICLE'S STOPPING DISTANCE WOULD BE INCREASED.Recall Details - 8/16/2006

2006 CHEVROLET KODIAK Recall - STEERING

Problem: ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.Recall Details - 10/4/2007
2005 Recalls ↓

2005 CHEVROLET KODIAK Recall - STEERING

Problem: ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.Recall Details - 10/4/2007

2005 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC:FLUID

Problem: CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME INTO CONTACT WITH A PORTION OF THE INTERMEDIATE STEERING SHAFT. A HOLE COULD BE WORN IN THE HOSE AND A LOSS OF HYDRAULIC FLUID WOULD OCCUR.Recall Details - 6/16/2005

2005 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC

Problem: CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS. Recall Details - 2/8/2005
2004 Recalls ↓

2004 CHEVROLET KODIAK Recall - STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

Problem: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. Recall Details - 3/17/2004

2004 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Problem: ON CERTAIN TRUCKS, THE SWITCH RETAINER HOLDING THE BRAKE BOOSTER PUSH ROD AND THE BRAKE PEDAL TOGETHER COULD BE MISSING. Recall Details - 3/10/2004

2004 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC

Problem: CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS. Recall Details - 2/8/2005

2004 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC:FLUID

Problem: CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME INTO CONTACT WITH A PORTION OF THE INTERMEDIATE STEERING SHAFT. A HOLE COULD BE WORN IN THE HOSE AND A LOSS OF HYDRAULIC FLUID WOULD OCCUR.Recall Details - 6/16/2005

2004 CHEVROLET KODIAK Recall - STEERING

Problem: ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.Recall Details - 10/4/2007
2003 Recalls ↓

2003 CHEVROLET KODIAK Recall - STEERING

Problem: ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.Recall Details - 10/4/2007

2003 CHEVROLET KODIAK Recall - SERVICE BRAKES, HYDRAULIC:FLUID

Problem: CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME INTO CONTACT WITH A PORTION OF THE INTERMEDIATE STEERING SHAFT. A HOLE COULD BE WORN IN THE HOSE AND A LOSS OF HYDRAULIC FLUID WOULD OCCUR.Recall Details - 6/16/2005

2003 CHEVROLET KODIAK Recall - ELECTRICAL SYSTEM:BATTERY:CABLES

Problem: CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH THE OPTIONAL CATERPILLAR DIESEL ENGINE (LG5) OPTION WERE BUILT WITH A MISROUTED BATTERY CABLE THAT COULD COME IN CONTACT WITH THE EXHAUST PIPE. THE CONDUIT AND THE NYLON CABLE COATING COULD DEGRADE TO THE POINT WHERE THE COPPER WIRE STRANDS OF THE CABLE ARE EXPOSED.Recall Details - 10/1/2002

2003 CHEVROLET KODIAK Recall - STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

Problem: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. Recall Details - 3/17/2004
1996 Recalls ↓

1996 CHEVROLET KODIAK Recall - PARKING BRAKE:CONVENTIONAL

Problem: THE AUTO-APPLY PARK BRAKE (MANUAL OR AUTO APPLICATION) DOES NOT ALWAYS APPLY. IF THE PARK BRAKE DOES NOT APPLY, THE "SERVICE PARK BRAKE" WARNING LIGHT WILL ILLUMINATE.Recall Details - 7/1/1996
1995 Recalls ↓

1995 CHEVROLET KODIAK Recall - EXTERIOR LIGHTING:BACK UP LIGHTS

Problem: THESE VEHICLES WERE ASSEMBLED WITH A TRANSMISSION REVERSE SIGNAL SWITCH THAT COULD LEAK CAUSING LOSS OF ELECTRICAL CONTACT WHEN THE TRANSMISSION IS IN REVERSE. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."Recall Details - 7/5/1995
1993 Recalls ↓

1993 CHEVROLET KODIAK Recall - STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

Problem: THE INTERMEDIATE STEERING SHAFT WAS ASSEMBLED WITH LOOSE OR MISSING UPPER AND LOWER PINCH BOLTS WHICH MAY CAUSE SEPARATION OF THE SHAFT.Recall Details - 1/8/1994
Home  •  Car Recalls  •  Tires  •  Motorcycles  •  RVs  •  Commercial Vehicles  •  Car Seats  •  Complaints  •  Sitemap  •  Privacy Policy

Edmunds  •  Kelley Blue Book  •  SaferCar.gov  •  Consumer Recalls  •  Government Recalls
Follow arfc_recalls on TwitterRSS Feeds