2019 HYUNDAI SANTA FE Complaints

My vehicle had a very strong gas smell inside and outside of the car. I found a gas puddle under the car coming from the back of the vehicle. Car was hesitating when I stepped on the gas. I was afraid it may stall. I drove the vehicle to my regular service station. Vehicle has an active fuel leak and this is a fire hazard. I was very concerned whether the vehicle would stall and cause an accident. Warranty coverage was denied.

Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ?Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ?Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ?Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ?Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ?Evidence Preservation: On August 31, 2026, the vehicle was towed to an independent facility to mitigate road hazards, conduct teardown diagnostics, and preserve the engine oil/filter for ISO-accredited spectrographic laboratory analysis. ?The manufacturer released an unsafe vehicle into traffic on August 20, 2026, and subsequently refused to investigate or remedy a documented internal engine failure that creates sudden, recurring loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle recently received the Hyundai 9c2 emissions upgrade they required and since then the vehicle has had predictable acceleration issues for the first several minutes after the vehicle. While trying to slowly accelerate the vehicle with unpredictably lurch forward. Many people have been reporting this.

The vehicle suffers from recurring, sudden loss of motive power and transitions into engine "limp mode" while driving in active, heavy traffic. This severe drivability defect has occurred on four separate occasions under Diagnostic Trouble Code (DTC) P00AF00 (Turbocharger/Supercharger Boost Control "A" Module Performance) and related boost/MAP faults (P0234). During these episodes, the vehicle abruptly loses acceleration capability without warning, creating an acute collision risk when navigating highway traffic and intersections. The turbocharger assembly has required replacement three separate times due to recurring oil contamination from the engine crankcase. Despite meticulous maintenance (documented synthetic oil changes every 3,000–5,000 miles since new), the manufacturer and dealership have repeatedly blamed peripheral turbo components rather than diagnosing or repairing the root cause (I suspect excessive engine crankcase pressure/piston ring blow-by based on the significant oil deposition on the turbo, map sensor, and pooling in the intake line).

Transmission was replaced under warranty by Hyundai in Nov 2024. Engine was replaced at 100600 miles in Nov 2025. Issues with the transmission were happening at that time but ignored by dealership as issues related to failing engine. Our mechanic confirmed in April that transmission was failing and told us to go to Hyundai. We went to dealer in April 2026. They confirmed transmission needed to be replaced. They were going to contact Hyundai USA. We received no updates despite many calls to the dealer. We had to call Hyundai USA directly. They opened a case. Dealer finally called and took car in and requested good faith repair by Hyundai USA. Hyundai USA responded 2 weeks later and is not covering anything. They replaced our transmission in Nov 2024 with a refurbished transmission that they NO LONGER MAKE. Clearly due to the fact that the refurbished part doesn’t work. They now want me to pay $8000 to repair transmission. My car has been maintained on schedule by my mechanic. All paperwork available. I have had Toyotas, Hondas and chevys that have lasted close to 20 years. This has been a horribly disappointing experience. And I now need to buy a new car for my 17 year old instead of handing down. I will NEVER buy another Hyundai. I want everyone to be aware of my experience. Disgusting customer service by Hyundai USA.

COMPLAINT SUMMARY: [XXX] / ENGINE THERMAL FIRE RISK / WARRANTY DECEPTION My 2019 Hyundai Santa Fe (2.4L GDI Engine) is experiencing severe powertrain degradation under the known Theta II engine defect class-action framework. On November 7, 2025, the vehicle logged a Permanent Diagnostic Trouble Code (DTC) P1326 via an independent scan, indicating catastrophic internal rod bearing wear. On XXX, the vehicle was brought to Hyundai of Milledgeville for safety recall verification. Instead of executing the mandatory corporate-directed Bearing Clearance Test (BCT) to replace the failing engine block, the service department committed technical campaign malpractice. The technician forced the 9C2 ECU Software Update directly over the locked mechanical fault to suppress the dashboard warning lights and alter the vehicle's ROM ID parameter limits. When caught via a photograph of their active GDS diagnostic tablet showing 7 historical system faults, the service manager provided a truncated printed report hiding Page 1 and omitting the critical P1326 powertrain code count to evade a warranty engine replacement. Due to these unmitigated delays, the vehicle has suffered severe consequential safety damage. The advanced engine degradation and oil consumption have flooded the exhaust system, melting the catalytic converter substrate and triggering a new DTC P042000 (Catalyst Efficiency) fault immediately after the dealer visit. The extreme engine vibrations have also damaged the transmission's torque converter clutch (DTC P074100). The dealership refused a service loaner and knowingly sent a disabled consumer and an elderly passenger away in an active, failing vehicle that presents a sudden stall-on-highway hazard and a severe thermal exhaust fire risk under extreme summer heat conditions. Hyundai Motor America Corporate has failed to provide emergency towing or alternative mobility accommodations despite a registered corporate case file. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

On March 04, 2026, I took my 2019 Hyundai Santa Fe to the local dealer for oil change service. As part of that service visit, they performed Hyundai recall 9C1 which was supposed to lower tailpipe emissions. The next morning, and ever since, my vehicle ran differently. The engine had several 1000rpm surges and was sluggish at other times. This behavior has continued. Particularly when I first start out in the morning and the engine is cold. Never after the engine is warmed up. A visit to the Hyundai forum shows a growing list of other Hyundai owners who are experiencing the same issues. This recall is defective and should be corrected.

My 2019 Hyundai Santa Fe 2.4L (VIN: [XXX]) is experiencing a severe safety defect involving rapid engine oil starvation. The vehicle recently failed an official oil consumption test conducted by Fred Beans Hyundai of Abington, where it was documented that the engine consumed 1 quart of oil in just 881 miles (PA Request #XXX). This vehicle is equipped with the Theta II engine, which currently has active warranty extensions (TXXC and TXXI) specifically covering connecting rod bearing failure. Despite the documented severe oil loss—which is the primary known cause of connecting rod bearing wear and sudden engine seizure—Hyundai Corporate (Case #XXX) is refusing to evaluate the vehicle under these warranties. They have improperly classified my claim as a denied "goodwill" request and are refusing to perform a connecting rod bearing clearance test to determine if the bearings have been damaged by this starvation. Because Hyundai refuses to perform the required diagnostic safety protocols, the vehicle must be driven in an oil-starved condition. This poses an imminent and severe safety risk of sudden engine seizure, stalling, and complete loss of motive power at highway speeds without warning, which could result in a catastrophic crash. The manufacturer is ignoring their own failure thresholds and putting driver safety at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In December 2025, a Hyundai dealer performed Service Campaign 9C2 (TSB 25-01-087H), an ECU software update for the 2.4L GDI Theta II engine, during a routine annual NY state emissions inspection. Immediately following this update, the vehicle began exhibiting an RPM flare of approximately 1,200-1,500 RPM during upshifting under light acceleration. This behavior did not exist prior to the update. The condition occurs when ambient temperature is above 50°F and the vehicle has been parked 2+ hours after a prior drive. No warning lamps or fault codes have been present at any point. The issue has been confirmed across four dealer visits at two Hyundai dealerships over five months. Attempted remedies included transmission ECU updates and adaptive resets — none resolved the condition. On the fourth visit, the technician personally experienced the issue and identified reinstalling the pre-update ECU calibration as the likely fix, but stated the prior software version was unavailable. The repair order was nonetheless closed as "vehicle operating as designed." The case has been escalated to Hyundai Motor America National Consumer Affairs and forwarded to Hyundai engineering with no resolution to date. Multiple other 2019-2020 Santa Fe owners report identical post-9C2 symptoms on public forums, indicating a pattern associated with this campaign's ECU calibration. The unexpected RPM surge and erratic shifting during acceleration creates an unpredictable driving experience that could cause hesitation in traffic situations requiring smooth acceleration.

Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across this vehicle generation; Hyundai acknowledged it by issuing Warranty Extension Z05 (TSB 25-BD-004H), which extends paint coverage to 10 years/unlimited miles for affected white-paint vehicles including the 2019 Santa Fe. Hyundai repaired the hood under this warranty in 2025, during which the vehicle was out of service for 77 consecutive days. Since that repair, the defect has migrated to the adjacent fender and has also appeared on a door, demonstrating that it is spreading across the vehicle. Hyundai has offered to repaint only the single currently-visible panel rather than addressing the systemic defect. I am filing this complaint to document the defect and its progression, and to support the public record regarding factory paint failure on these vehicles. No crash, injury, or fire has resulted. The vehicle is owned by my spouse; I am submitting as authorized representative. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)