2025 TOYOTA GRAND HIGHLANDER Complaints

Load cabin wind noise. Service said it was the luggage bars on the roof. I removed the bars and the noise was the same. Came back to the shop on August 22, 2026 they looked and said the panoramic seal was lifting and leaking. Before buying the car we were told the prior issue with panoramic sunroofs leaking had been resolved. In addition the plastic handle that controls the middle seat broke off after using it three times.

I have noticed on several separate occasions a strong gas odor coming from my 2025 Toyota Grand Highlander after I have completed a drive. This has been intermittent, however, yesterday on XXX, the gasoline odor was so strong after I parked my vehicle in my garage, that it quickly filled the garage with an overwhelming odor. My son urgently came to get me when he stepped into the garage and realized how strong the fumes were. We had to open the garage to air it out. I called the Larry Miller Peoria Toyota dealership immediately and had my vehicle inspected the following day on XXX. I was informed by the service advisor that Toyota receives numerous complaints daily about this very issue with the newer model Highlanders, Grand Highlanders, Tacomas, and 4Runners. I insisted that my vehicle be inspected. The report stated that they were unable to duplicate the condition. The report states that no leaks were found with the evap system. The report also states that whe outside temps are extremely high, fuel inside the tank expands and creates additional vapor. I was assured by the service team that the fuel tank is operating correctly, despite the overwhelming fuel vapors that are intermittently emitted. I have lived in [XXX] my entire life and I have never encountered this issue with any vehicle that I have owned. These fumes are toxic and I am very concerned about my family being exposed and our safety/wellbeing. I have installed a carbon monoxide monitor in my garage. I have also filed a formal complaint at the Corporate level within Toyota and am awaiting a response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I continuously have issues accelerating from stop in my max hybrid. the issue is particularly worse when it is warm out. I press the gas and the RPMs drop really low and I barely move through the intersection for a few seconds. Once it finally registers after a number of seconds, the RPMs rev up over 4000. It is very dangerous trying to proceed through an intersection and the car basically stalls when I press the gas. It especially concerns me that I have my child in the car with me and I worry when it is going to act up. I know others have experienced this issue and there was a TSB for 2024 models that had this issue. I have a 2025 and experience this issue. I have had toyota look at it and they said they cant do the TSB since it's bot for my VIN. A solution needs to be found for the the safety of myself and others.

I have over 30k miles on my car. Over the period that I’ve owned it there have been a few, roughly 6, occasions where I’m trying to change lanes from a stop into quick traffic and my car lags 1-3 seconds in response to me pressing the gas petal. It happens infrequently and is not the normal response. Other times the car responds as one would expect.

on 8/13/2026, I was driving alone on West I-80 right before Park City, Ut; I heard a loud pop and my panoramic sunroof exploded which was really scary. I was not using my sunroof at all, so the cover protected everything on the inside. At first I thought it was a flat tire, but no warning messages came onto the control panel. There were not immediate safety issues, so I was able to get to a Toyota Dealership to have it repaired. I did not hear any gravel or road debris flip up onto my sunroof, nor did I hear any under my tires when driving. My vehicle was inspected by a service technician at the Toyota Dealership and he just said it was probably caused by an outside influence.

My wife was driving and a small rock passed through the front grill puncturing the radiator and causing her check engine light to come on. Within 5 minutes the coolant leaked out and the car was undrivable. We took it to Bredemann Toyota in Park Ridge who replaced it.

Rodent damage to plant based wiring to Engine Harness A and valve vacuum hose. Cost $1700 and 2 repairs.

Driving on highway and suddenly panoramic sunroof glass shattered spontaneously. It nearly caused us to crash into median due to the sudden extremely loud noise that sounded like a gunshot at close range and then the sound of glass shattering and hitting into sunroof shade and top of car. My 18 year old daughter was driving and it was extremely scary for her and myself. No nearby vehicles on either side of the road or near an overpass. We were fortunately near an exit and able to safely remove vehicle from road. I feel extremely lucky that no accident or injury occurred and credit my daughter's ability to stay calm and not panic at highway speed. To date, the car insurance company Travelers states it is not covered as there was no accident and dealership states it is not a warranty item (but they have escalated it to Toyota corporate for further review) and no one is willing to repair it so far (including stand alone glass companies!). But it will certainly be several thousand dollars in repairs. In the meantime I cannot drive my car when there is any chance of rain or really at highway speed. No warning prior, no history of any cracks or damage to sunroof prior. The car is just barely 1 year old.

The component that was available for inspection was our gas tank. It provided a profuse smell of fumes coming out of the tank and/or exhaust. You could also see vapors coming out of the gas tank when driving. The fumes alone are extremely toxic and extreme levels. The safety of me, my two young children and husband is all at risk. The smell of the gas and the view of the vapors from the gas tank puts the vehicle at an extreme fire risk. The smell of the fumes out it at a toxic inhalant risk - especially having two young children. This has caused great fear within me and the safety of my children is at extreme risk. No. I have taken the vehicle to the dealer 2-3 times, advised each time there is no issue with the vehicle. However, the smell of the gasoline has happened 6-8 times since purchasing the vehicle in May 2025. The vehicle has only been inspected by the dealer. Unsure who else to bring it to. The first time it was towed because the smell of the gas was in the cabin of the vehicle and I did not feel safe having my two small children in it with the extreme gas smell. No, no warning lamps. No indicators. The first time it happened I was alone with my two small children and the only indicator was the vapors coming out of the tank that were visible, and the extreme smell of the gasoline when I would roll my window down.

After a complete stop at a stop sign there is hesitation/stalling when trying to accelerate. Sometimes the hesitation is several seconds and then the engine kicks in and lurches forward. Couple times this has been a safety issue as it happens when I’m trying to pull out on a busy road. The delay/hesitation has caused me to almost get hit a few times. There are no lights or warning messages when this happens. It happens a multiple times a week especially during hot weather when AC is on full (LO temp setting and maximum fan) and is usually during the first few minutes of operation usually at the same stop signs on my route to pickup my kids after the car has been sitting unused overnight. I also notice that the hybrid battery indicator is usually always at 3 bars. Dealership hasn’t been able to reproduce as it's a very specific scenario (not driving/in garage overnight and short drive). Instead they went and applied T-SB-0040-25 but this hesitation is still happening after the software update. This needs to be handled like a safety issue/recall worthy with a complete fix! Not just some drivability issue that only gets applied if we ask about specific T-SBs.